Fevereiro 2015 vol. 1 num. 2 - XX Congresso Brasileiro de Engenharia Química

Artigo - Open Access.

Idioma principal

Fructooligosaccharides production in aqueous system using commercial and home-made inulinase after treatment in pressurized fluids

SILVA, M. F. ; RIGO, D. ; MOSSI, V. ; GOLUNSKI, S. ; KUHN, G. O. ; MARCON, N. S. ; DALLAGO, R. ; MAZZUTTI, M. A. ; TRES, M. V. ; OLIVEIRA, J. V. ; OLIVEIRA, D. ; TREICHEL, H. ;

Artigo:

Fructoligosaccharides (FOS) are food additives with several health benefits, especially in the digestive tube, where they act as prebiotics presenting several advantages over other oligosaccharides synthesized industrially. This work is focused on the synthesis of fructooligosaccharides (FOS) from sucrose and inulin using free, immobilized and pre-treated inulinases from Kluyveromyces marxianus NRRL Y 7571 and Aspergillus niger in aqueous system. Initially, the influence of the different gases (propane, n-butane and LPG) on FOS production was investigated. The best results were achieved when both enzymes were previously treated with LPG. For the synthesis of FOS using inulinases from Aspergillus niger, 56.98% of GF2 and 8.47% of GF4, was obtained using inulin as substrate. Using inulinases from Kluyveromyces marxianus NRRL Y 7571, 4.8% of GF2, 5.47% of GF3 and 4.27% of GF4 was achieved, also using inulin as substrate. 1. INTRODUCTION Inulinases can be obtained from yeasts, fungus, bacteria and plants (Manzoni and Cavazzoni 1992). Special attention is given to the enzymes produced by Kluyveromyces Área temática: Engenharia e Tecnologia de Alimentos 1marxianus and Aspergillus niger, that presents promising activity on the substrate sucrose and inulin (Linde et al. 2012). These enzymes can be used in hydrolysis processes of inulin aiming at obtaining fructose syrup and fructooligosaccharides, and also in the oligosaccharides synthesis from sucrose (Risso

Artigo:

Palavras-chave:

DOI: 10.5151/chemeng-cobeq2014-1142-20783-145883-fi

Referências bibliográficas
  • [1] HAYASHI, S., KINOSHITA, J., NONOGUCHI, M., TAKASAKI, Y., IMADA, K. Continuous production of 1-kestose by β-fructofuranosidase immobilized on shirasu porous glass. Biotech. Letters 13, 395-398, 199
  • [2] LINDE, D., RODRÍGUEZ-COLINAS, B., ESTÉVEZ, M., POVEDA, A., PLOU, F.J., LOBATO, M.F. Analysis of neofructooligosaccharides production mediated by the extracellular β- fructofuranosidase from Xanthophyllomyces dendrorhous. Biores. Technol. 123, 234-237, 201
  • [3] MANZONI, M., CAVAZZONI, V. Hydrolysis of Topinambur (Jerusalem Artichoke) Fructans by Extracellular Inulinase of Kluyveromyces marxianus var. bulgaricus. J. Chem. Technol. Biotechnol.199, 311-315, 1992.
  • [4] MAZUTTI, M.A., ZABOT, G., BONI, G., SKOVRONSKI, A., OLIVEIRA, D., DI LUCCIO, M., RODRIGUES, M.I., TREICHEL, H., MAUGERI, F. Optimization of inulinase production by solid-state fermentation in a packed-bed bioreactor, J. Chem. Technol. Biotechnol. 85, 109-114, 2010.
  • [5] RISSO, F.V.A., MAZUTTI, M.A., TREICHEL, H., COSTA, F., MAUGERI, F., RODRIGUES, M.I. Comparison between systems for synthesis of fructooligosaccharides from sucrose using free inulinase from Kluyveromyces marxianus NRRL Y-7571. Food Bioproc. Technol. 5, 331-337, 2012.
  • [6] SANTOS, A.M.P., MAUGERI, F. Synthesis of fructooligosaccharides from sucrose using inulinase from Kluyveromyces marxianus. Food Technol. Biotech. 45, 181-186, 2007.
  • [7] SILVA, M.F., GOLUNSKI, S.M., RIGO, D., MOSSI, V., DI LUCCIO, M., MAZUTTI, M.A., OLIVEIRA, D., OLIVEIRA, J.V., TREICHEL. H. Pressurized Propane: An Alternative Technique to Increase Inulinase Activity, Ind. Biotechnol. 8, 293-299, 2012.
  • [8] SILVA, M.F., GOLUNSKI, S.M., RIGO, D., MOSSI, V., DI LUCCIO, M., MAZUTTI, M.A., PERGHER, S.B.C., OLIVEIRA, D., OLIVEIRA, J.V., TREICHEL, H. Liquefied petroleum gas as solvent medium for the treatment of immobilized inulinases. J. Chem. Technol. Biotechnol. 91, 54-59, 2013a. SILVA, M.F., RIGO, D., MOSSI, V., GOLUNSKI, S.M., KUHN, G., DI LUCCIO, M., DALLAGO, R., OLIVEIRA, D., OLIVEIRA, J.V., TREICHEL, H. Enzymatic synthesis of fructooligosaccharides by inulinases from Aspergillus niger and Kluyveromyces marxianus NRRL Y-7571 in aqueous–organic medium. Food Chem. 138, 148-153, 2013b. TIAN, F., KARBOUNE, S. Enzymatic synthesis of fructoligosaccharides by levansucrose from Bacillus amyloliquefaciens: Specificity, kinetics and product characterization. J. Mol. Catal. B: Enzymatic. 82, 71-79, 2012.
  • [9] TREICHEL, H., OLIVEIRA, D., LERIN, L., ASTOLFI, V., MAZUTTI, M.A., DI LUCCIO, M., OLIVEIRA, J.V. A review on the production and partial characterization of microbial inulinases. Global J. Biochem. 3, 7-19, 2012.
Como citar:

SILVA, M. F.; RIGO, D.; MOSSI, V.; GOLUNSKI, S.; KUHN, G. O.; MARCON, N. S.; DALLAGO, R.; MAZZUTTI, M. A.; TRES, M. V.; OLIVEIRA, J. V.; OLIVEIRA, D.; TREICHEL, H.; "Fructooligosaccharides production in aqueous system using commercial and home-made inulinase after treatment in pressurized fluids", p. 4334-4341 . In: Anais do XX Congresso Brasileiro de Engenharia Química - COBEQ 2014 [= Blucher Chemical Engineering Proceedings, v.1, n.2]. São Paulo: Blucher, 2015.
ISSN 2359-1757, DOI 10.5151/chemeng-cobeq2014-1142-20783-145883-fi

últimos 30 dias | último ano | desde a publicação


downloads


visualizações


indexações